Multiple customer requested items, new ceiling, general going through of all systems, modify couch, coat roof, etc
Date(s): March 8, 2010. Album by Dan Hellier. Photos by Dan. 1 - 72 of 72 Total. 6173 Visits.
1 Day one, shored on blocks and wheels pulled off.
9 Besides the other places where the breaks are more visible, there are long cracks in the cpvc tubing. If you look closely, just behind the coupling there is a crack that extends all the way back through the wall.The easiest repair is to just replace all the plumbing with pex.
11 March 18th, lots of work done today.
13 Old water heater.
14 Old water heater removed, will be replaced with Ariston 4 gallon electric water heater.
15 Previous fresh water holding tank. Removed and discarded. It weighed about 40 pounds.
16 New roof vent and new roof coating.
21 Large areas of rot in the corner and all along the bottom looking forward.
22 Making a splice piece to tie everything together in the corner.
23 Splice piece intstalled.
24 Outside view of the splice piece where the corner weight is dispersed in both directions.
26 The corner all put back together, as I start to run out of daylight.
32 New Ariston 4 gallon hot water heater. Unfortunately the only place it would fit is in the bottom of the closet.
34 Getting ready to close the back wall up.
35 Customer requested addition to the couch.
36 Some of the new pex connections.
38 Cold water connection to the toilet, under the front left bench seat.
39 Kitchen faucet hot and cold lines.
41 Top lifts for storage.
43 Whats left of the existing ceiling.
44 All the ceiling pulled out. The area in the back of the picture is the rounded part over the bunk.
45 Here's where I made a piece of square wood round, boy was that fun.
46 The tape marks are where the beams are, so I could make chalk lines after the piece was in.
51 March 21st, last of the ceiling is in.
52 Old bathroom ceiling and old light fixture.
53 New water lines at Shower faucet.
55 I added a board and re-attached the drawer guides as they were completely detached.
56 New Bathroom ceiling minus light fixture.
57 New light fixture.
58 New gas line coming to stove. The smaller line brances off and goes to the gas light.
60 Preparing to flare the new gas line.
61 Flaring the gas line.
62 Hard to see in this picture or the next, but if you look closely you can see the blue flames. All burners work, no problem.
64 New pressure regulator installed. Gas system was soap tested, and pressure sustaining tested.
65 New Shower assembly complete.
66 March 28, Kilz Primer
67 Paint, hard to see in the pictures. It's more of an egg shell / light brown, it was color matched to the original ceiling.