Put interior in a 44 foot race car trailer. For more info about what we do,please visit our main web site www.ncrvsolutions.com or www.trickmytrailer.org That's DOT ORG
Date(s): December 15, 2008. Album by daniel hellier. Photos by Dan Hellier. 1 - 149 of 149 Total. 212 Visits.
1 Start Date, December 06, 2008
2
3
4
5
6
7
8
9
10
11 12-7-08
12 Fresh Water Tank and 10 gallon hot water heater.
13
14 New Faucet
15 12 volt main boxes, main wiring harness
16 1 of 2 junction boxes for 12 volt overhead lights, fans, etc
21 Dec 10. The existing 12 volt overhead lights were tied into the tow vehicle clearance lights circuit. They needed to be re-wired to the "house battery system"
22
23 This is the spot for the roof vent fan to be installed, also the junction for the center ceiling lighting.
24 Tie in for aft lights and aft roof vent box fan
25
26
27
28 New 12 volt fuse box. Switch is for 12 volt water pump.
29 Switch for 110 volt water heater
30 12 volt water pump
31
32
33
34
35
36
37 Amplified T.V. Antennae
38 December 13, 2008 Measure 46 and a half times, cut once. I only get one shot at lining everything up.
39
40
41
42
43
44
45
46
47
48 December 14. Seal existing walls around shower pan.
49
50 This is the only 20 inch wide bay. The only bay the black water tank will fit in to. This conduit and wiring needs to be re-routed through another bay.
51 Close up look at where the toilet will directly line up with the black tank.
52 Placing the black water tank.
53 Initial placement of the first of two grey water holding tanks. Each grey tank has a capacity of 16 gallons, for a total of 32 gallons total.
54
55
56
57 Toilet flange lined up with cutout through floor and into tank.
58 If you look closely you can see right down into the black water tank.
59 December 17. Install new diamond plate power strip.
60 Install switch to existing work light above counter.
61 Power to the center row of lights. Switch for all center aisle lights next to entrance door.
62 rear two center lights.
63 Power to sink light.
64 Power to L/H upper bunk light.
65 Power up to forward junction box. T.V. Antennae amplifier / switch assembly hanging.
66 Rear junction box completed.
67 Shower pan permanently mounted and sealed. Toilet base permanently mounted and sealed.
68
69 Rear overhead vent, box fan installed. Just a small fan to help rid rear area of fumes.
70 Fan & switch completely installed.
71 December 20th. I was definately "up with the sun" this morning.
72 Forward roof vent removed.
73 New Shur-flow fan roof vent being installed.
74
75 Roof vent covers. These things are great and worth every penny.
76 Inside look at new fan.
77 Inside view of rear roof vent cover.
78 Rear Roof vent cover.
79
80 Prepping for installing the R/H window.
81
82 R/H Window
83 L/H Window
84 L/H Window
85 December 24th, partition wall added, other small plumbing issues done today along with 3rd holding tank installed.
86
87
88
89
90
91 L/H Window Complete
92 R/H Window Complete
93 T.V. Antennae Installed.
94
95 Inside view of antennae, initial install.
96 L/H Battery Bracket
97 R/H Battery Bracket
98 L/H Battery Isolation Connector.
99 Internal Wiring, battery wiring, tow harness wiring all coming together.
100 R/H Battery Isolator Connector
101 December 28, 2008 Installing holding brackets for black water tank.
102
103
104 Inter-Connects for two gray water tanks.
105
106 2 Way tank blade valve.
107
108
109 Running new wires, to previously moved 110 volt wires under belly.
110 Previous rigid conduit replaced with flexible conduit.
111 Junction box, center forward beam, just under nose compartment. "Nice conversion but shouldn't you us..." View Comments...
112
113 December 31, 2008 Location of air conditioner. The back end will hang out into the out side compartment.
114
115
116
117
118
119
120 Preliminary shower wall.
121
122 Preliminary wall with faucet back board.
123
124 1-1-2009 Toilet feed water line
125 Shower hot and cold feed lines
126
127
128 Shower faucet installed, view from bunk.
129
130 Top of the line R.V. water saving shower head.
131
132
133 New Kidde Smoke Alarm. (Compliments of NC RV Solutions)
134 Shower Light
135 12 volt power strip.
136
137 12 Volt Oscillating Fan
138 Antennae Handle
139 Fire Extinguisher. (Compliments of NC RV Solutions)
140
141
142 January 3, 2009 Fabricate and install shower curtain rod.
143 Previously damaged tow vehicle to trailer harness.
144 All new butt splices
145
146 Back side of shower wall. Project Complete ! January 3, 2009
147 For the picture album of this re-furbishment, copy and paste the link below.
http://imageevent.com/shastaproject
148 My rainy day project. Re-furbish this 1970's Serro Scotty to almost like new condition. No picture site yet, I haven't started this one yet.
149 To See this brand new toy hauler built, copy and paste the link below to go to this picture site.
